Testing Capacitor-How To Test A Capacitor When Breakdown Under Load

Have you ever come across power problem where once you switch on the power supply and the fuse blow? You have checked all the components in the power (primary) and secondary section and all the components seems to be ok! Where is the fault? A fuse blown are usually caused by a shorted bridge rectifier, defective posistor, power transistor or FET, shorted primary winding of switch mode power tranformer, shorted secondary diode and etc. But in this article i'm gone to show you another secret of electronic troubleshooting tips.

I got frustrated as to where is the cause of power problem. Everytime when i switch on the power supply the fuse blow immediately (the fuse became dark color and this indicate that there is a major short circuit in the power supply). I have checked all the components in the power supply and can't find the culprit! What i do is i desoldered all the suspected parts one by one and replaced with a known good component. I eventually found the caused of the power supply problem. Guess what? It was the main filter capacitor (220 microfarad 400 volt). After replacing the filter cap the power supply worked perfectly fine. I begin my detective work to find out why this capacitor can caused the fuse to blow eventhough i already confirmed it ok with my meters.

The meters that i used to check the filter cap were analog meter, digital capacitance meter and esr meter. In this article i will not explain about how to check capacitor or testing capacitor and how capacitor work. I believed most of you know how to check capacitors and also generally using this type of meters. Measured with analog it showed capacitor charging and discharge, with digital capacitor tester it showed around 220 microfarad and with esr meter it showed low esr reading!

This proved that the bad capacitor breakdown when under full operating voltage. Then, how do i confirm that this filter capacitor is faulty? By using an analog insulation tester. When i connect the faulty cap to the meter and press the go button-it showed a very low resistance and this is the proved of short circuit between the plate when voltage applied! There is nothing to do with bad electrolyte. A good capacitor will just showed a charge and discharge in the insulation meter just like you are checking a capacitor using analog multimeter. In the market there is quite a number of ranges that you can buy. It has the range of 50v, 100v, 250v, 500v, 1000v and even 5000v! If you want to test a capacitor of 100 microfarad 160v then you have to select 100v. If you select 250v, it will blow your capacitor that is under test.

If you have the SENCORE TEST EQUIPMENT such as the sencore lc meter LC102 OR LC103, these meters have the capabilities of checking any type of capacitors with four tests:
-testing for capacitor values
-checking for leakage
-equivalent series resistance (ESR) and
-Dielectric absorption

It can check aluminum electrolytic capacitor, film capacitor, ceramic, high voltage capacitor and etc.

Conclusion-Different capacitor manufacturer produced different type of quality of a capacitor. Perhaps the bad capacitor that I encountered are from the lowest grade one. A capacitor failure when under load is very rare. Using ESR capacitor meter alone can solve most of the electrolytic capacitor problem.

Jestine Yong is a electronic repairer and a writer. For more electronic repair information please visit his website at http://www.noahtec.com/electronic-repai r-articles.htm

---

Getting A New Laptop At A Great Price

With all the wheeling and dealing that seems to take... Read More

War of the Disks: A Close-in Analysis of the Hard Disk Drive vs. the Solid State Disk

Much has been written about solid state disks (SSDs) becoming... Read More

Buying a New Computer

Someone recently asked me "I teach senior citizens in a... Read More

Does Size Really Matter In Our Digital Age?

Well, we've all seen the advert, but that's not what... Read More

Digital Cameras, Media, and Card Readers

With the dropping prices on digital cameras and digital media... Read More

Understanding Transistor Data and Replacement

If, for some reason, you can't get an exact replacement... Read More

Alternatives to Tape Backup

You may ask, isn't tape an anachronism in the age... Read More

The Top 10 Must-Have Laptop Accessories

You've laid out good money for your laptop computer, but... Read More

The Making of Energy Efficient Datacenters

The Crooked E: The Unshredded Truth About Enron is a... Read More

At War With The Internet

When it comes to sales of technology products over the... Read More

RAID Disk Recovery

RAID is short for Redundant Array of Independent (or Inexpensive)... Read More

Survey of Both Past and Modern Printers

Printers are on-line devices initially categorised as being either impact... Read More

Hard Drive Selection

Perhaps the biggest mistake people make when building their computer(s)... Read More

Rear Projection TV Facts - Understanding the Pros & Cons of Rear Projection in the Home Theater

Rear Projection Television - An Affordable OptionA great deal of... Read More

Small Computers

Today, small form factor computers demolish the myth that bigger... Read More

How To Upgrade Your PC

Before you upgrade your PC hardware it's best to search... Read More

What Tablet PCs Can Do for You

Tablet PCs are great. If you are a mobile person,... Read More

ATA vs SATA

Hard Drives: ATA versus SATAThe performance of computer systems has... Read More

A Review of Samsung Laser Toners

Samsung laser toner is just as popular as its Hewlett-Packard... Read More

Discover Everything About Wholesale Bar Code Reader And Software!

It is a given fact that buying wholesale would make... Read More

You Can Prevent Computer Slowdowns & Issues

Most people understand preventive maintenance like changing the oil in... Read More

Laptop and Notebook Theft Prevention

Laptops or Notebook computers are an expensive personal and business... Read More

The Merging of Humans and Computers

Soon the human brain will be completely interfaced with the... Read More

How to Shop for Inkjet Printer Cartridges

Keeping Shipping Costs DownWhen shopping for inkjet printer cartridges online... Read More

How To Purchase A Quality Laptop Computers Case

So you finally have that new laptop you have been... Read More

Wireless Notebooks: What You Need To Know About Going Wireless!

It's not exactly breaking news that our world is becoming... Read More

Purchasing Laser Toner Refills

Laser toner refills can be expensive. Over the life of... Read More

The Constantly Changing World of Inkjet Technology

We have finally advanced to a time when technology can... Read More

Tips To Select Proper Motherboard

Selecting motherboard is really simple. As name suggests "Motherboard" acts... Read More

Inexpensive Radius Server Gives Wireless Networks The Security They Need

Many small businesses have considered connecting computers and other devices... Read More

What is ESR Meter?

All capacitors have a certain amount of resistance to the... Read More

Advanced Tips on Speeding Up Your PC

Other then keeping your HDD free of viruses, spyware, and... Read More

How to Add or Remove an IDE ROM drive

CD ROMS - If you're adding or removing an internal... Read More