Testing Diode -The Accurate Way on How to Test Semiconductor Diode Using Multimeter

Testing diodes is different from testing a resistor because you need a skill to do it. If you do not know or wrongly test a diode you will be unable to repair the equipment. A bad diode you think it is good. This will definitely waste your precious time.

A rectifier diode can fail in one of the four ways. It can become:

-Open
-Shorted
-Leaky
-Breakdown when in full operating voltage

An analog multimeter or digital multimeter can be used to check for all the first three conditions except the last one where the diode breakdown in full operating voltage. From my of experienced in the electronic repairing line, i found that checking diode using analog multimeter is more accurate than using a digital multimeter. I could explain to you why i preferred analog meter. I do not know about you because i really came across quite a number of diodes where it checked ok using digital multimeter but failed when test with analog meter.

The first step on how to test a diode is to remove one of the diode lead. You can't always be certain if a diode is good or bad if you perform in-circuit test, because of back circuits through other components. To be absolutely sure, you will need to lift, or disconnect, one diode lead from the circuit to avoid back circuits. Unless you are very sure about the board you are checking. Sometimes i do found bad diodes when checking it on board. Your experienced will tell you when to check a diode on-board or off-board. If you are new to electronic repair, i highly recommend that you check a diode with a lead removed from the board.

I will set my analog meter to x1 ohms to check for current diode leakage reverse and forward testing. Connecting the black probe of your meter to the cathode and red probe to the anode, the diode is reverse biased and should look like an open reading. Connecting the red probe of your meter to the cathode and black probe to the anode, the diode is forward biased and the meter should read some value of resistance. If you have two readings then most probably the diode is shorted or leaky and you should replace it. If you don't get any reading either forward or reverse bias, the diode is considered open.

The real problem when checking a diode using the diode test function of a digital meter is that an open or leaky diode, the meter sometimes reads ok(0.6). This is due to digital meter diode test output voltage (which you can measure the output test probe using another meter) is around 500mv to 2v. An analog meter set to x1 ohms have output about 3V(remember the two 1.5V battery you installed in the meter!). The 3V voltage is enough to show you the accurate reading of a diode when under test.

Even if you have a good reading at x1 ohms doesn't mean that the diode is good . You now have to set your meter to x10K to test the diode again. The output voltage of x10k ohms is about 12V(remember the 9v battery in your meter-1.5v+1.5v+9v=12v). Again the diode under test should show only one reading. This is exception to Schottky diode where it have two readings but not shorted reading. If the meter showed one reading then the diode under test is good. If it has two readings then most probably the diode is either shorted or leaky. The digital meter can't test it because the output from the meter is only 500mv to 2V.

If a diode breakdown when under full operating voltage, there is no way to testing diode (unless you have a very expensive diode checker which specially designed to locate this type of problem).Substituting with a known good diode is often the only way to prove that an intermittent diode is causing a particular problem. Sometimes an intermittent diode could be locate using a coolant spray.

Caution: Be certain that power is removed from any circuit before performing any of the following diode checks, otherwise meter or circuit damage could result.

Conclusion-In order to correctly test diode function you need to set the analog meter to x1 ohms and x10K ohms range.

Jestine Yong is a electronic repairer and a writer. For more electronic repair information please visit his website at http://www.noahtec.com/electronic-repai r-articles.htm

---

What is ESR Meter?

All capacitors have a certain amount of resistance to the... Read More

Trouble-shooting Hard Drive Problems - Part 1

It is extremely important not to make or write any... Read More

How to Purchase a Flat Panel TV

When purchasing a flat panel TV, there are a few... Read More

How To Save Big Bucks On A Laptop Computer

If you're a bargain shopper looking to get the most... Read More

Basics of RAID

A couple of the recent Tech Tips from www.geeks.com have... Read More

What Tablet PCs Can Do for You

Tablet PCs are great. If you are a mobile person,... Read More

Printers: What Really Happens When You Hit ?Print?

You just poured hours upon hours into a lengthy research... Read More

Flash Your ATI Video Cards BIOS

Flash your ATI video card BIOS.You will need the following:1.... Read More

Buying / Selecting Computer Components

This is the step takes the most time and consideration.... Read More

Computer Parts Online

In today's age, building computers on yourself is often chosen... Read More

Selecting an Ink Jet printer?With Low Operating Cost

Printer technology has made tremendous advances in the past five... Read More

How To Refill Your Ink Cartridge

Forget about emptying your wallets every time you see the... Read More

Give Your PC a Monitor Makeover

Whether you are crunching figures at a front office job... Read More

Facing DVD Software Dilemma? Its Brainlessly Simple

The Pocket DVD Wizard allows you to make backup copies... Read More

Digital Cameras, Media, and Card Readers

With the dropping prices on digital cameras and digital media... Read More

Printer Ink Cartridges - The History

You are working at your computer and trying to print... Read More

Review of Popular Wireless Headphones

Just about everyone would I agree, I think, that wires... Read More

An Introduction to Tape Backup

If you run a small business, chances are you're saving... Read More

Used Laptop Computer: Your Quick Purchase Inspection Guide ? Part 4

Used laptop computers are everywhere these days. How can you... Read More

Wireless Notebooks: What You Need To Know About Going Wireless!

It's not exactly breaking news that our world is becoming... Read More

Discover Everything About Wholesale Bar Code Reader And Software!

It is a given fact that buying wholesale would make... Read More

The Constantly Changing World of Inkjet Technology

We have finally advanced to a time when technology can... Read More

An Inexpensive Solution to Securing Public Access Computers

Offering secure public Internet access is not as easy as... Read More

JunxionBox -- WiFi Access Everywhere

Now you can more easily access the Internet wherever mobile... Read More

Two Essential Accessories For Notebook Computers

A Good Notebook BagForget those that are bundled with your... Read More

Buying Laser Toner Cartridges

Compatible Laser Toner CartridgesRecently, there has been a huge legal... Read More

A Look Inside The Elusive Inkjet Industry

The Inkjet printer industry is booming. Office supply companies report... Read More

5 Ways To Backup Your Data...

The data on your hard drive is the most critical... Read More

How To Stop Junk Faxes From Wasting Your Paper and Toner

Junk faxes waste the resources of every business. It is... Read More

Ceramic Disc Capacitor-How to Accurately Test It

The last article I mentioned about electrolytic capacitor breakdown when... Read More

Dusting Your Computer - Keeping it Cool

My mother always told me to dust, but I never... Read More

Laptop Computers and the PVP Effect!

Roll over lumbering desktop computers, the limber laptop is here,... Read More

Hard Drive Selection

Perhaps the biggest mistake people make when building their computer(s)... Read More